MATERIAL SAFTEY DATA SHEET
THE CORTEC CORPORATION
4119 WHITE BEAR PARKWAY
ST. PAUL, MINNESOTA 55110
PHONE: 651-429-1100 OR TOLL FREE 1-800-4-CORTEC
FAX: 651-429-1122
EMERGENCY PHONE NO.: CHEMTREC (FOR SPILL, LEAK, FIRE, EXPOSURE OR ACCIDENT): 1-800-424-9300 (DAY OR NIGHT)
* * * * * * * * * EcoSpray Electronic Cleaner 238 * * * * * * * * * *
SECTION I - PRODUCT IDENTIFICATION
PRODUCT NAME: EcoSpray Electronic Cleaner 238
PRODUCT DESCRIPTION: A proprietary blend of corrosion inhibitors in a solvent carrier.
SECTION II - HAZARDOUS INGREDIENTS
|
INGREDIENT NAME(S) |
WEIGHT (%) |
OCCUPATIONAL EXPOSURE LIMITS |
||
|
TLV OR PEL |
ORAL LD-50 |
|||
|
Mineral spirits CAS #64742-48-9 |
70-80 |
100 ppm (ACGIH) |
N.E. |
|
Carcinogenic: OSHA = no NTP = no IARC = no
SECTION III - PHYSICAL DATA
COLOR: Clear slightly yellow PHYSICAL FORM: Liquid
NON-VOLATILE (weight): 7-10% pH: N.E.
VAPOR DENSITY: N.E. ODOR: Petroleum
VAPOR PRESSURE: N.E. BOILING RANGE: N.E.
EVAPORATION RATE: N.E. MELTING RANGE: N.A.
DENSITY: 6.5-6.8 lb/gal (0.78-0.81 kg/l)
SECTION IV - FIRE AND EXPLOSION DATA
HMIS FLAMMABILITY RATING: 2
FLASH POINT: 177ºF (80ºC)
FLAMMABLE LIMITS: LEL: 1.3 UEL: 8.8 (77ºF/25ºC)
EXTINGUISHING MEDIA: Carbon dioxide or other dry chemical fire fighting agents.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should wear self-contained breathing apparatus.
SECTION V - HEALTH HAZARD DATA
EMERGENCY AND FIRST AID PROCEDURES:
Eye Contact: Flush eyes with water for at least 15 minutes. Consult a physician. Skin Contact: Wash affected area with soap and water. If irritation persists, consult a physician. Inhalation: Remove to an uncontaminated area, administer oxygen if necessary. If victim has stopped breathing begin CPR. Get medical attention. Ingestion: If conscious, give water but do not induce vomiting. Get immediate medical attention.
MEDICAL CONDITIONS PRONE TO AGGRAVATION BY
EXPOSURE: None known
PRIMARY ROUTES OF ENTRY: Skin contact.
HEALTH HAZARDS (acute and chronic) / EFFECTS OF OVEREXPOSURE:
1. Repeated or prolonged skin contact with this material can cause moderate irritation and defatting of skin leading to possible chronic dermatitis.
2. Contact of eye tissues with liquid and/or high vapor concentrations may cause eye irritation.
3. Excessive inhalation of high vapor concentrations and/or particle mists of this product may cause nasal and respiratory irritation, dizziness, weakness, fatigue, nausea, headache and possible unconsciousness. An LD-50 value for inhalation of mineral spirit vapors is listed in literature as 3,400 ppm for 4 hours in laboratory animals.
4. Ingestion of this product is expected to cause gastrointestinal irritation. Also, aspiration of this material into the lungs can cause chemical pneumonia.
SECTION VI - REACTIVITY DATA
STABILITY: Stable
HAZARDOUS POLYMERIZATION: Will not occur
HAZARDOUS DECOMPOSITION PRODUCTS (Under fire conditions): Oxides of carbon and nitrogen.
INCOMPATIBILITY: Avoid contact with strong acids, alkalis and oxidizing agents.
CONDITIONS TO AVOID: Contact with incompatible materials.
SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Absorb on sweeping compound or other absorbent material.
WASTE DISPOSAL: Incinerate or dispose of in accordance with existing Federal, State and Local environmental regulations.
SECTION VIII - SAFE HANDLING AND USE INFORMATION
RESPIRATORY PROTECTION: A NIOSH approved respirator is recommended when used in closely confined areas.
PROTECTIVE GLOVES: Not necessary.
EYE PROTECTION: Safety goggles.
OTHER PROTECTIVE EQUIPMENT: Not necessary.
SECTION IX - SPECIAL PRECAUTIONS AND STORAGE DATA
PRECAUTIONS TO BE TAKEN IN HANDLING: Avoid eye and skin contact. Avoid excessive inhalation of vapors and/or particle mists. Use in a well-ventilated environment.
PRECAUTIONS TO BE TAKEN IN STORING: Keep containers tightly closed. Store below 100ºF (38ºC) and away from heat or open flame.
SECTION X - SHIPPING DATA
DOT/IATA/IMDG SHIPPING NAME: Petroleum distillates, nos.
UN/NA NUMBER: 1268
DOT/IATA HAZARD CLASS: 3
T.S.C.A. STATUS: Listed
DOT/IATA REQUIRED LABELS: Flammable liquid
TECHNICAL SHIPPING NAME: Mineral Spirits
IMDG HAZARD CLASS: 3.3
IMDG CODE: Page 3375, Amdt. 28-96
PREPARED BY: Margarita Kharshan, R&D Manager
APPROVED BY: Christophe Chandler, Lab Director
DATE PREPARED: 8/18/00 SUPERSEDES: 4/8/99
DISCLAIMER: This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of the Cortec Corporation. The data on this sheet relates only to the specific material designated herein. The Cortec Corporation assumes no legal responsibility for use or reliance upon this data.
N.E. = NOT ESTABLISHED N.A. = NOT APPLICABLE